Diye Energy
Programa de secado de productos agrícolas y derivados
Programa de secado de productos agrícolas y derivados Inicio / Agricultural and sideline product...
Programa de secado de productos agrícolas y derivados
Programa de secado de productos agrícolas y derivados
Applications: grain, fruit, vegetables, nuts, meat products, soy products, pickled products, condiments, cash crops, noodles, tobacco leaves, silkworm cocoons, etc.
The advantages of agricultural product dryers are as follows:
1. The agricultural product dryer is an intelligent device integrating dehumidification, heating, cooling, temperature exhausting and ventilation, and is a new type of drying equipment for energy saving and emission reduction.
2. The intermediate heat exchange, dehumidification and dehumidification of the double-effect dehumidification technology greatly improves the dehumidification performance ratio, and the energy saving effect is obvious. Jiangxi Tianquan Thermal Energy Technology must achieve its mission.
3. Break through the technical bottleneck of traditional dehumidifiers and ordinary heat pump dehumidification dryers: solve the technical problems of poor dehumidification performance of traditional dehumidifiers under high temperature and low humidity conditions or even idling (the compressor does not remove water when running).
4. Unique exhaust heat recovery design: reduce heat loss and better overall energy saving;
5. The advanced fresh air pre-dehumidification function can ensure fresh air drying, suitable for strict drying process;
6.The high-temperature heat pump drying unit is an environmentally friendly and energy-saving drying equipment. It will not produce any harmful substances during the drying process, and there will be no smoke or open flames during the drying process. The temperature and humidity can be adjusted according to the characteristics of the drying materials. , with a high degree of intelligence.In industry, agriculture and chemical industry, drying technology is closely related to our production and life. The heat pump dryer is environmentally friendly and energy-saving, automatically controls temperature and humidity, has a wide range of applications, and is less affected by climate. It is widely used in agriculture, forestry, animal husbandry and fishery industries such as dried noodles.
7.There is no need for special personnel to take care of the drying process. After the material is dried or the drying temperature reaches the drying temperature, the unit will automatically shut down to achieve the effect of energy saving. The unit operates at normal temperature and pressure. The biggest feature is in energy saving. Tube infrared microwave energy saving more than 50%, 40% energy saving than oil burning, 20% – 30% energy saving than coal burning, and the unit will generate cold air during the drying process, and the cold air is directly discharged into the workshop to increase the room temperature.
8.Easy installation: easy installation and demolition, small footprint, can be installed indoors and outdoors;
9.High efficiency and energy saving: It only needs to consume a small amount of electric energy to absorb a lot of heat in the air, and the power consumption is only 1/4 of the electric heater; compared with coal, oil and gas-fired dryers, it can save energy 60% of the running cost. 1 kWh is equal to 4 kWh.
10.Environmental protection and pollution-free: without any combustion and emissions, it is a sustainable and environmentally friendly product. For the drying temperature that entrepreneurs and friends are concerned about, this depends on the specific formula and moisture content. For most agricultural products, 50-60 degrees Celsius is already suitable. Too high drying temperature is not conducive to the appearance, and is not conducive to the preservation of flavor and nutrition.
11.Safe and reliable operation: The operation of the entire system is free from the dangers of inflammable, explosive, poisoning, short circuit and other possible existing in traditional dryers (fuel, gas or electric heating). It is an absolutely safe and reliable semi-closed drying system.
10Consulta
Cuéntenos qué necesita secar
Envíe su material, el peso por lote y el objetivo de humedad. Respondemos con un modelo, una disposición de cámara y una estimación de coste de uso — normalmente en un día laborable.